Opel Astra, Zafira

since 1998 of release

Repair and car operation



Opel Astra
+ Opel Astra and Zafira Cars
+ Operation manual
+ Routine maintenance
+ Engine
- Systems of cooling, heating
   Specifications
   Antifreeze - general information
   + System of cooling of the engine
   - Systems of ventilation, salon and air conditioning heating
      Removal and installation of deflectors of air lines
      Removal and installation of resistive assembly of the driving electromotor of the fan of a heater
      Removal and installation of the driving electromotor of the fan of a heater
      Removal and control panel installation by functioning of systems of heating / ventilation / air conditioning
      Removal and installation of the main case of a heater
      Removal and installation of the heat exchanger of a heater
      Removal and installation of the switch of a heater
      Check of serviceability of functioning and service of systems of heating and air conditioning
      Removal and installation of the compressor of central air of air
      Removal and installation of the evaporator of central air of air
      Removal and installation of the condenser of central air of air
      Removal and installation of a receiver dehumidifier of central air of air
      Removal and installation of the additional fan
+ Power supply system and release
+ engine Electric equipment
+ Manual transmission
+ Automatic transmission
+ Coupling and power shafts
+ Brake system
+ Suspension bracket and steering
+ Body
+ Onboard electric equipment




Removal and installation of the condenser of central air of air

 PERFORMANCE ORDER

  1. Make central air discharge in the conditions of a specialized workshop.
  2. At the corresponding complete set open a cowl and disconnect electroconducting from the electromotor of the additional fan of system of cooling located under a front bumper.
  3. Turn out bolts and disconnect refrigerator tubes from the condenser and a receiver dehumidifier. Disconnect electroconducting from the pressure sensor switch in system.
  4. Turn out bolts of fastening of a receiver dehumidifier.
  5. Turn out the top bolts of fastening of the condenser to a radiator and remove it from the bottom basic clamps. Remove the condenser assembled with a receiver dehumidifier.
  6. In case of need the receiver dehumidifier can be separated from the condenser.

Installation is made upside-down.

The recharge of central air should be made in the conditions of a car-care center workshop.