Opel Astra, Zafira

since 1998 of release

Repair and car operation



Opel Astra
+ Opel Astra and Zafira Cars
+ Operation manual
+ Routine maintenance
+ Engine
+ Systems of cooling, heating
+ Power supply system and release
- Engine electric equipment
   Specifications
   + Electronic control system of ignition (and injection) petrol engines
   + Systems of preheat and heating of fuel of the diesel engine
   - Charge and start systems
      The storage battery - the general information, condition check, replacement, storage and commissioning
      Check of a condition and replacement of wires of the battery
      Check of serviceability of functioning and condition of components of system of a charge
      Removal and installation of a natyazhitel of a driving belt of the generator
      Removal and generator installation
      Replacement of brushes of the generator
      Check of serviceability of functioning of a condition of components of system of start
      Removal and starter installation
      Check of a condition and regenerative repair of a starter
+ Manual transmission
+ Automatic transmission
+ Coupling and power shafts
+ Brake system
+ Suspension bracket and steering
+ Body
+ Onboard electric equipment

http://flashlottos24.ru/


Check of serviceability of functioning of a condition of components of system of start

Before starting performance of checks of functioning of a starter make sure that the reason of the complicated start is not low level of a charge of the battery.

If the starter does not rotate at all at ignition key turn in the situation START, first of all, make the following elementary checks:

  • Check level of a charge of the battery, and also a condition and reliability of fastening of wires on plugs of the battery and the traction relay of a starter.
  • Check a condition of wires of the battery (see. Check of a condition and replacement of wires of the battery). Defective components replace.
  • Check a battery condition (see. The storage battery - the general information, condition check, replacement, storage and commissioning). In case of need replace it new.
  • Check a condition of electroconducting and terminal connections of a starter (see. Head Onboard electric equipment, Schematic diagrams of electric connections).
  • Check reliability of a tightening of bolts of fastening of a starter.
  • At the corresponding complete set check a condition of fusible inserts in the assembly block in an impellent compartment of the car (see. Head Onboard electric equipment). If any of inserts failed, make investigation and elimination of the reasons of an overload. Also check serviceability of functioning of a chain of the switch of ignition (see. Head Onboard electric equipment).
  • Check serviceability of functioning of the sensor switch of permission of start (model with AT) / switching off of a chain of a starter (model with RKPP). Start of the engine can be carried out only in a case when the lever of the selector of transfers is established in the situation "R" or "N" (AT), or the pedal of coupling (RKPP) is squeezed completely out.
  • Check serviceability of functioning of the relay of inclusion of the starter located in the assembly block of safety locks/relay in an impellent compartment of the car (see. Head Onboard electric equipment).

For check of a condition of the battery include headlights, - if brightness of their luminescence in some seconds sharply falls, therefore, the battery is discharged, - make additional charge (see. Head Routine maintenance), or replace the battery (see. The storage battery - the general information, condition check, replacement, storage and commissioning). If headlights burn brightly, include a starter and watch lamps. If activation of a starter leads to decrease in brightness of a luminescence of headlights it means that the current reaches the electromotor of a starter and malfunction is covered actually in assembly of the last. If brightness of a luminescence of headlights does not change and there is no click of operation of the traction relay violation of serviceability of functioning of the relay, or damage to a chain of its electroconducting (see below), therefore, takes place. If the starter turns the engine too poorly, and level of a charge of the battery is in norm, means or the electromotor is faulty, or resistance in a chain of system of start is exceeded.

For check of a chain disconnect wires from the battery (including the grounding tire on a body element). Also disconnect electroconducting of the traction relay and the thick cable crossing point connecting the block of the engine to a body. Carefully smooth out all contact connections, then restore initial connection of electroconducting and use the voltmeter or a lamp sampler for stock-taking of full tension of the battery on a positive wire going to the traction relay, also "ring out" a negative wire. Grease terminal knots of the battery with technical vaseline.

If the battery and contact connections are found serviceable, check a chain, having disconnected a wire from the traction relay. Connect a lamp sampler between the disconnected wire and weight (pure metal of a body or the negative plug of the battery). Include ignition, make sure of integrity of the conductor, - if the lamp burns, therefore, breaks are not present.

Contacts of the involving relay can be checked if to attach the voltmeter or a lamp sampler between a positive wire in a place of its accession to the motor of a starter and "earth". If to include a starter, the lamp should be shone or to be the corresponding tension on the voltmeter indicator. If is not present – it is faulty the involving relay, it is necessary to replace it.

If the chain and the traction relay are serviceable, it is necessary to demolish a starter in a car-care center workshop for check of a condition of its internal components and carrying out necessary regenerative repair, - before make sure that cost of repair will not exceed cost of replaceable knot.